Also, ensure the thermocouple is not more than an inch from the pilot to ensure heat emitted reaches the pilot. To remedy this issue, replace the thermocouple if it is damaged. If the thermocouple does not stay hot enough, it will not allow gas to flow to the pilot tube. If the pilot light is still going out, then the issue could be the thermocouple. Also, ensure the pilot vent is clear to prevent air blockage. Ensure the gas heater is placed in a well-ventilated area that does not have direct access to drafty windows or doors. On the other hand, too little wind will affect the pilot light as well. To remedy this situation, ensure you place the heater away from the room’s drafty part being heated. This is because too much wind will keep putting off the flame. Another cause of a malfunctioning pilot is a draft. If the lighter is not emitting blue light, it is dirty and needs to be cleaned. Then check to see if the gas valve is working and clean it or replace it as needed. Lastly, check to see if the electronic spark mechanismis defective.Turn off the gas and turn on the heater to see if you see a spark when you turn on the heater. Ideally, at least two-thirds of the sensor should be covered by the flame. In this case, you can remedy the issue by cleaning the heater’s flame sensor. This can be as a result of a malfunctioning pilot or thermocouple. Auto-shutoffĪ defective flame may cause the heater’s safety feature to shut off the heater automatically. This false trigger to the safety failsafe will shut off your Mr.Buddy heater. Sometimes, a faulty thermocouple won’t detect the heat and will unwittingly shut down the gas valve. However, if there is no flame to heat it up, the thermocouple will interpret this as a problem forcing the gas valve shut. This ‘tells’ the thermocouple that everything is alright and it can keep the gas valve open. When everything is working fine, the flame from the pilot light or the actual heater heats up the thermocouple. The thermocouple iprevents the heater from releasing unburnt gas into the invironment. Note that the pilot light will be off until you turn on the heater
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |